Paul, Yes, I'm going to switch Y and LM dampers, if the problem comes back after some printing there must be something wrong with the ink. It's only the Y-line that struggles. After some printing the nozzles slowly disappears. This is a short version of what's done: Humidity is under control. The level o CFS/ink bottles are adjusted. Every joint and o-ring checked. Y damper cleaned three times. Capping station adjustment is done. The CFS-cart is replaced with an Epson original cart as there always was a lot of foam in the MIS cart. Switched Y/LM damper place, the problem followed the Y-line. Switched the Y/LM tubes. Both lines worked. The Y damper was just cleaned. And "some" cleaning, normal and kk2, and purge file printing. Best Hans >Hans, > >The UT1 warm curve does not use the toner to any significant degree. The >green curve has to be dropped to turn on the black ink, but if there were >nothing in the LM jet, you probably would not notice the difference. > >(I assume you're going to take the LM damper and put it on the Yellow line.) > >Paul >www.PaulRoark.com > > >> -----Original Message----- >> From: Hans & Chia [mailto:chiahans@...] >> Sent: Wednesday, March 09, 2005 2:14 PM >> To: DigitalBlackandWhiteThePrint@yahoogroups.com >> Subject: [Digital BW] To Paul R, UT1 and 7500 >> >> >> Hello Paul, >> >> When using your warm curve is the light toner (LM) in use at all? >> There are no toner between 50-100%. >> The "yellow line" has been struggling for weeks >> and I can't get a new damper quick enough. >> Have tried "everything" with very good help from a list member. >> It's a long story so I stop here. >> >> Hans >> -- >> Atelier Pictoform >> Chia N-Löfqvist & Hans Nohlberg >> Hedåsgatan 5 >> SE-412 53 Göteborg >> SWEDEN >> >> +46 (0)31181414 >> Mobile: 073 974 44 24 >> (Besök/visit Hedåsgatan 6) >> >> http://www.pictoform.nu >> >> >> >> Please visit the Group Homepage to check the Files, and other resources as >> they are often being updated. >> >> http://groups.yahoo.com/group/DigitalBlackandWhiteThePrint >> >> If you wish to receive no emails or just a daily digest, or you wish to >> unsubscribe, please edit your Membership preferences by visiting this same >> page. >> >> Please follow these basic guidelines: >> - As threads develop, trim off excess portions of earlier messages to keep >> them short. >> - Good manners are required at all time. No personal attacks or flames. >> Hostile, aggressive or argumentative users may be removed from the >> membership without notice. >> - Keep your posts and threads related to the group topic of digital B&W >> printing. Users who persistently make off-topic posts may be removed from >> the membership. >> - By posting on this forum you agree to abide by the group rules and >> guidelines, and to abide by the actions and decisions of the group Owner >> and Moderators. See Group Topic, Rules and Guidelines in the Files >> section: >> http://groups.yahoo.com/group/DigitalBlackandWhiteThePrint/files/ >> >> BY PARTICIPATING IN AND/OR POSTING MESSAGES TO THE DIGITAL BW, THE PRINT >> YAHOO! GROUP YOU EXPRESSLY UNDERSTAND AND AGREE THAT THE OWNER AND >> MODERATORS OF DIGITAL BW, THE PRINT YAHOO GROUP SHALL NOT BE LIABLE TO >> YOU FOR ANY DIRECT, INDIRECT, INCIDENTAL, SPECIAL, CONSEQUENTIAL OR >> EXEMPLARY DAMAGES, INCLUDING BUT NOT LIMITED TO, DAMAGES FOR LOSS OF >> PROFITS, GOODWILL, USE, DATA OR OTHER INTANGIBLE LOSSES (EVEN IF THE >> OWNER AND MODERATORS OF DIGITAL BW, THE PRINT YAHOO GROUP HAVE BEEN >> ADVISED OF THE POSSIBILITY OF SUCH DAMAGES), RESULTING FROM: (i) THE USE >> OR THE INABILITY TO USE THE DIGITAL BW, THE PRINT YAHOO GROUP; (ii) >> UNAUTHORIZED ACCESS TO OR ALTERATION OF YOUR TRANSMISSIONS OR DATA; (iii) >> STATEMENTS OR CONDUCT OF ANY THIRD PARTY ON THE DIGITAL BW, THE PRINT >> YAHOO GROUP; OR (iv) ANY OTHER MATTER RELATING TO THE DIGITAL BW, THE >> PRINT YAHOO GROUP. >> >> Yahoo! Groups Links >> >> >> >> >> >> > > > > > > >Please visit the Group Homepage to check the >Files, and other resources as they are often >being updated. > >http://groups.yahoo.com/group/DigitalBlackandWhiteThePrint > >If you wish to receive no emails or just a daily >digest, or you wish to unsubscribe, please edit >your Membership preferences by visiting this >same page. > >Please follow these basic guidelines: >- As threads develop, trim off excess portions >of earlier messages to keep them short. >- Good manners are required at all time. No >personal attacks or flames. Hostile, aggressive >or argumentative users may be removed from the >membership without notice. >- Keep your posts and threads related to the >group topic of digital B&W printing. Users who >persistently make off-topic posts may be removed >from the membership. >- By posting on this forum you agree to abide by >the group rules and guidelines, and to abide by >the actions and decisions of the group Owner and >Moderators. See Group Topic, Rules and >Guidelines in the Files section: >http://groups.yahoo.com/group/DigitalBlackandWhiteThePrint/files/ > >BY PARTICIPATING IN AND/OR POSTING MESSAGES TO >THE DIGITAL BW, THE PRINT YAHOO! GROUP YOU >EXPRESSLY UNDERSTAND AND AGREE THAT THE OWNER >AND MODERATORS OF DIGITAL BW, THE PRINT YAHOO >GROUP SHALL NOT BE LIABLE TO YOU FOR ANY DIRECT, >INDIRECT, INCIDENTAL, SPECIAL, CONSEQUENTIAL OR >EXEMPLARY DAMAGES, INCLUDING BUT NOT LIMITED TO, >DAMAGES FOR LOSS OF PROFITS, GOODWILL, USE, DATA >OR OTHER INTANGIBLE LOSSES (EVEN IF THE OWNER >AND MODERATORS OF DIGITAL BW, THE PRINT YAHOO >GROUP HAVE BEEN ADVISED OF THE POSSIBILITY OF >SUCH DAMAGES), RESULTING FROM: (i) THE USE OR >THE INABILITY TO USE THE DIGITAL BW, THE PRINT >YAHOO GROUP; (ii) UNAUTHORIZED ACCESS TO OR >ALTERATION OF YOUR TRANSMISSIONS OR DATA; (iii) >STATEMENTS OR CONDUCT OF ANY THIRD PARTY ON THE >DIGITAL BW, THE PRINT YAHOO GROUP; OR (iv) ANY >OTHER MATTER RELATING TO THE DIGITAL BW, THE >PRINT YAHOO GROUP. > >Yahoo! Groups Links > > > > -- Atelier Pictoform Chia N-Löfqvist & Hans Nohlberg Hedåsgatan 5 SE-412 53 Göteborg SWEDEN +46 (0)31181414 Mobile: 073 974 44 24 (Besök/visit Hedåsgatan 6) http://www.pictoform.nu http://www.etsabild.se http://www.artphotocollection.com
Message
RE: [Digital BW] To Paul R, UT1 and 7500
2005-03-10 by Hans & Chia